Battery cable sets

Golf Cart Parts and

Golf Cart Accessories

golf Carts Unlimited

Each cable expertly crafted to give years of service.

Some sets contain 4 different cable lug ends.

Each cable end is sealed to inhibit corrosion.
Cable sets ship in 24-48 hours

Email us with questions about your cart

or for more information email
scottyb@cartsunlimited.net

Club Car Series

1992 - 2006

Club Car IQ

New SR controls require longer lengths

12 inch

Single cables with 5/16ths standard or 3/8ths ends for MZJ400 solenoid or SW202

$15.50

$44.00

About paypal checkout - If you select an option from the drop down menu select MORE info in checkout to reveal those selections to us.

How to order

1.Determine if your cart is sepex or series drive Click here if unsure

2. Find the kit that fit your cart.

3. Use the drop down menus to select specific voltage and batteries

4. Select Standard F&R or SW202 reversing contactor for 3/8 lugs.

EZGO SERIES

* OBC is the common accronym for the On Board Computer.

From 1995 - 2013.5 Club Car used an OBC to control the battery charging system. The main (-) battery cable runs through a small hole in this computer. The computer tracks the amperage flow.

The OEM cable end must be cut off to remove the cable and a double ended stud is installed in the hole so the new larger cable can be attached at each side of the OBC.

Stud kit and simple install instruction supplied where needed.

See illustration below

24 inch

#16 Ezgo TXT Battery cable sets of 5 - 7 pieces

Choose your options before adding to cart.

1. 36 volts. 5 Battery to battery cables for six 6 volt batteries.

2. 48 volts. 5 Battery to battery cables for six 8 volt batteries.

3. 48 volts. 7 Battery to battery cables for eight 6 volt batteries.

Home page

$34.50

2 gauge 10 piece cable set for the G29

with six 8v batteries. $219

Big controllers need big cables for unrestricted amperage flow

and optimum performance. Select 5/16 solenoid ends for 200 a Sw180 solenoid as used with the 400 amp controller. Or select 3/8 ends for the MZJ400 solenoid used with the 500 amp controller

Select 4/12v batteries (white border)

Or select 6/8v batteries (red border)

Ezgo 1994 - present Medalist & TXT series carts

Fits all 3 & 4 terminal controllers.

This kit for both 3 and 4 terminal controllers when 4th terminal A2 not used.

Terminal A2 discontinued in modern controls. Terminal A2 should not be used

For Ezgo carts with environmental controller cover removed.

Kit # 2 = 2 gauge 13pc complete cable set

DS Series controller carts 1991 & up

36 & 48v carts with or without on board computer .

Kit # 6 = 14pc 2g cable set For use with aftermarket controllers

For carts with Aftermarket controllers & motors. For carts with big tires or steep hills

From the drop down menu select with or with on board computer.

Also select standard F&R or reversing contactor SW202 (3/8th lugs)

#17 Club Car DS Battery cable sets of 5 pieces

Choose your options before adding to cart.

1. 36 volts. 5 Battery to battery cables for six 6 volt batteries.

2. 48 volts. 5 Battery to battery cables for six 8 volt batteries.

$12.00

$17.50

Single cables & partial sets below

EZGO SEPEX

We offer 2 gauge cable sets
for upgraded carts with aftermarket controllers.

When it comes to battery cables bigger is better.

A 36 volt system uses more amperage

than a 48 volt system to the same job.

So 36v requires a bigger cable

We use 2g on everything.

Bigger controllers & motors will draw more amperage

& require the bigger 2g cable.

#18 Club Car IQ Battery cable sets of 3 - 5 pieces

Choose your options before adding to cart.

1. 48 volts. 3 Battery to battery cables for four 12 volt batteries.

2. 48 volts. 5 Battery to battery cables for six 8 volt batteries.

Each cable end should be protected from corrosion.

Commercial corrosion inhibitors are available at any auto parts house. You can use any spray on or petroleum jell that will seal the lug against exposure to the air and

the acidic vapors released during battery charging

#15 Ezgo Marathon Battery cable sets of 5-7 pieces

Choose your options before adding to cart.

1. 36 volts. 5 Battery to battery cables for six 6 volt batteries.

2. 48 volts. 5 Battery to battery cables for six 8 volt batteries.

3. 48 volts. 7 Battery to battery cables for eight 6 volt batteries.

Made in the USA
Custom Cables Sets
Made from the finest USA made Copper Cable & Terminal Lugs
2 gauge is over 600 strand welding cable

This big cable in a tough acid resistant jacket is extremely flexible
Flexible Neoprene Jacket
All connections are sealed against outside corrosion.

Made in the USA

$16.50

18 inch

About paypal checkout - If you select an option from the drop down menu select MORE info in checkout to reveal those selections to us.

Cables come with numbered identification and instruction includes a picture diagram showing where each number cable goes. If you can turn a wrench and follow the numbers this is a level 1 upgrade.

The install is simple and fun.